[
SUPPORT - Battery Guide ]
Battery Guide
Motorcycle Battery Maintenace
Tips to keep your motorcycle at peak condition.
Motorcycle maintenance is more than doing maintenance on your
motorcycle because you have to do it now or it is time to do it
right away. On going general maintenance will keep your
motorcycle in great condition with little or no unpleasant
surprises on the road.
Typical Motorcycle Battery
Motorcycle Battery Maintenance
Tip: There are dozens of parts on a
motorcycle that could be checked on a regular basis and there is
nothing wrong with check all those parts. But try to slim the list
down to the most important items so you still have time to ride.
The Battery
THE BASICS
First things first. A 12-volt battery is not
a 12-volt battery. Twelve volts is just a nominal, convenient term
used to distinguish one battery from another. A fully-charged
12-volt battery, allowed to "rest" for a few hours (or days) with no
load being drawn from it (or charge going to it), will balance out
its charge and measure about 12.6 volts between terminals.
When a battery reads only 12 volts under the
above conditions, it's almost fully depleted. Actually, if a
battery's resting voltage is only 12.0 to 12.1 it means only 20 to
25% of its useful energy remains. It's either a goner or it has been
deep cycled, and a battery can only be deep-cycled a limited number
of times before it is indeed dead.
12-volt batteries supply useful energy only
through a limited range -- from over 14 volts (when fully charged
and unrested) down to 10.5 volts in use/under load (when lights dim,
your motorcycle is hard to start). No 12-volt battery will remain at
over 14 volts for more than seconds unless it's being charged. The
lowest limit is 10.5 volts (used in testing) and obviously
unsatisfactory in practical use.
NOTES: Keep in mind that listed voltages are "Resting" Volts.
Maintaining Your Battery
Tip: Check the fluid levels on each
chamber. If any chamber is low, carefully top it up. Use only
distilled or deionized water, NOT tap water. Tap water has minerals
in it that will not do the battery any good.
The humble battery is a very common cause for
motorcycle breakdowns! Unfortunately they are awkward to get to and
therefore do not get checked as often as they should.
A battery only requires a little monthly
maintenance to perform perfectly. Keep the battery charged to 100%,
recharging when the lights dim, the starter sounds weak, or the
battery hasn't been used in more than two weeks. Other than that,
follow this simple check list every month:
- Check the electrolyte level
- Top up only with distilled or deionized water, wear gloves and
protective glasses. Top up in a well ventilated area, Beware of
fumes.
- Keep the top free of grime
- Check cables, clamps, and case for obvious damage or loose
connections
- Clean terminals and connectors as necessary
- Check inside for excessive sediment, sulfation or mossing
- Make sure the exhaust tube is free of kinks and clogs
- Replace caps firmly
- Finish up by testing the battery with either a hydrometer or
voltmeter. To extend the service life of your battery, make monthly
battery maintenance part of your routine.
Use only distilled or deionized water, NOT
tap water. Tap water has minerals in it that will not do the battery
any good.
Storage can be hard on batteries. In fact,
non-use can leave them unable to hold a charge.
Store your bike in a place that is always
warmer than 32 degrees. If your bike is outside remove the battery
from your bike and store it in a location that is always warmer than
32 degrees. This will insure that your battery does not freeze and
crack.
If you remove the battery from your bike DO NOT store it on a
concrete or metal surface, place the battery on a wood or other
non-conductive surface. Batteries stored on concrete or metal will
discharge over time.
Place a charger on your battery. Trickle charge your battery at
least once a month. A battery that is fully charged will have a
longer life and is less likely to freeze during cold winter weather.
Safety - Proper Clothing
Always wear a face shield or safety goggles.
Wear plastic gloves to prevent acid burns. An apron or smock will
protect your clothes.
Working With Acid
Clean up acid spills immediately using a
water and baking soda solution to neutralize (1lb. baking soda in 1
gallon of water).
Make sure the acid container is clearly marked and the work area is
well-lighted and well-ventilated.
If sulfuric acid is swallowed or splashed in the eyes, treat
immediately. Sulfuric acid in the eyes can cause blindness. Serious
internal injuries or death can result if swallowed. Used as an
electrolyte, sulfuric acid can burn the skin.
ANTIDOTES: For acid on the skin, flush with water. If acid is
swallowed drink large quantities of milk or water, followed by milk
of magnesia, vegetable oil or beaten eggs. Do not induce vomiting.
Call a poison control center or doctor immediately. For acid in the
eyes, flush for several minutes with water and seek immediate
medical attention.
Charging Safety
When charging conventional batteries, loosen
vent caps and ventilate charging area. A buildup of hydrogen and
oxygen in the battery or in the charging area can create an
explosion hazard.
If the battery feels hot to the touch during charging, STOP. Allow
the battery to cool before charging again. Heat damages the plates,
and a battery that is too hot can explode.
NEVER put the red sealing cap back on the battery once you take it
off. If you do, gases will become trapped and could explode.
Make sure the vent tube isn't kinked or blocked. Otherwise, gases
could build up and explode.
Properly connect the charger to the battery: positive charger lead
to positive battery post and negative charger lead to negative
battery post. Unplug the charger or turn it off before you
disconnect the leads, which will cut down on the chance of sparks.
ABSOLUTELY NO SMOKING, SPARKS OR FLAMES AROUND CHARGING BATTERIES.
Charging gives off hydrogen and oxygen, which explode if ignited.
Selecting the Proper Battery
It's easier than you think to buy the wrong battery for your
vehicle. Unless your current battery is definitely the original
equipment, you're taking a chance by not double checking before you
purchase the new battery. You can search for a certain battery, but
there are a few general rules you should know before you search.
If the battery for your vehicle is
sensor-equipped, remember to replace the sensor at the same time you
change the battery.
Never swap a Maintenance Free battery for another battery unless the
Applications book says it's OK.
When given the option of several different batteries for your
vehicle, choose the one that will give you what you want
performance-wise. It's up to you.
Always make sure you have the right battery before you charge and
install it. Save yourself the hassle (and money) of having to buy
another battery.
|